Cultivation of previously uncultured microorganisms with a continuous-flow down-flow hanging sponge (DHS) bioreactor, using a syntrophic archaeon culture obtained from deep marine sediment as a case study

Hiroyuki Imachi, Masaru K. Nobu, Masayuki Miyazaki, Eiji Tasumi, Yumi Saito, Sanae Sakai, Miyuki Ogawara, Akiyoshi Ohashi, Ken Takai

Published: 2022-09-13 DOI: 10.1038/s41596-022-00735-1

down-flow hanging sponge bioreactor

uncultured microorganisms

syntrophic archaeon

deep marine sediment

anaerobic incubation

AI 解读

Supplementary information

Supplementary Information

Supplementary Table 1, Supplementary Note 1 and Supplementary Figs. 1–8

Reporting Summary

Fabrication of angstrom-scale two-dimensional channels for mass transport

Efficient and strand-specific profiling of replicating chromatin with enrichment and sequencing of protein-associated nascent DNA in mammalian cells

The eINTACT method for studying nuclear changes in host plant cells targeted by bacterial effectors in native infection contexts

Rapid reaction optimization by robust and economical quantitative benchtop19F NMR spectroscopy

Profiling native pulmonary basement membrane stiffness using atomic force microscopy

Photoimmunotechnology as a powerful biological tool for molecular-based elimination of target cells and microbes, including bacteria, fungi and viruses

Measuring key human carbohydrate digestive enzyme activities using high-performance anion-exchange chromatography with pulsed amperometric detection

Neural cell isolation from adult macaques for high-throughput analyses and neurosphere cultures

Preparation, validation and use of a vasoactive tryptophan-derived hydroperoxide and relevant control compounds

Neuronal subtype-specific growth cone and soma purification from mammalian CNS via fractionation and fluorescent sorting for subcellular analyses and spatial mapping of local transcriptomes and proteomes

查看全部

Sections

Figures

References

Supplementary information

Flemming, H.-C. & Wuertz, S. Bacteria and archaea on Earth and their abundance in biofilms. Nat. Rev. Microbiol. 17, 247–260 (2019).
Inagaki, F. et al. Exploring deep microbial life in coal-bearing sediment down to ~2.5 km below the ocean floor. Science 349, 420–424 (2015).
Bar-On, Y. M., Phillips, R. & Milo, R. The biomass distribution on Earth. Proc. Natl Acad. Sci. USA 115, 6506–6511 (2018).
D’Hondt, K. et al. Microbiome innovations for a sustainable future. Nat. Microbiol. 6, 138–142 (2021).
Lloyd, K. G., Steen, A. D., Ladau, J., Yin, J. & Crosby, L. Phylogenetically novel uncultured microbial cells dominate earth microbiomes. mSystems 3, e00055-18 (2018).
Lewis, W. H., Tahon, G., Geesink, P., Sousa, D. Z. & Ettema, T. J. G. Innovations to culturing the uncultured microbial majority. Nat. Rev. Microbiol. 19, 225–240 (2021).
Nayfach, S. et al. A genomic catalog of Earth’s microbiomes. Nat. Biotechnol. 39, 499–509 (2021).
Rinke, C. et al. Insights into the phylogeny and coding potential of microbial dark matter. Nature 499, 431–437 (2013).
Hugenholtz, P. Exploring prokaryotic diversity in the genomic era. Genome Biol. 3, REVIEWS0003 (2002).
Engelen, B. & Imachi, H. Cultivation of subseafloor prokaryotic life in developments in marine geology. In Earth and Life Processes Discovered from Subseafloor Environment. Vol. 7 (eds. Stein, R., Blackman, D., Inagaki, F. & Larsen, H.-L.) 197–209 (Elsevier, 2014).
Baker, B. J., Appler, K. E. & Gong, X. New microbial biodiversity in marine sediments. Annu. Rev. Mar. Sci. 13, 161–175 (2021).
Hoshino, T. et al. Global diversity of microbial communities in marine sediment. Proc. Natl Acad. Sci. USA 117, 27587–27597 (2020).
Tahon, G., Geesink, P. & Ettema, T. J. G. Expanding archaeal diversity and phylogeny: past, present, and future. Annu. Rev. Microbiol. 75, 359–381 (2021).
Bhattarai, S., Cassarini, C. & Lens, P. N. L. Physiology and distribution of archaeal methanotrophs that couple anaerobic oxidation of methane with sulfate reduction. Microbiol. Mol. Biol. Rev. 83, e00074-18 (2019).
Krukenberg, V. et al. Gene expression and ultrastructure of meso- and thermophilic methanotrophic consortia. Environ. Microbiol. 20, 1651–1666 (2018).
Wegener, G., Krukenberg, V., Ruff, S. E., Kellermann, M. Y. & Knittel, K. Metabolic capabilities of microorganisms involved in and associated with the anaerobic oxidation of methane. Front. Microbiol. 7, 46 (2016).
Agrawal, L. K. et al. Treatment of raw sewage in a temperate climate using a UASB reactor and the hanging sponge cubes process. Water Sci. Technol. 36, 433–440 (1997).
Tyagi, V. K. et al. Future perspectives of energy saving down-flow hanging sponge (DHS) technology for wastewater valorization—a review. Rev. Environ. Sci. Biotechnol. 20, 389–418 (2021).
Namita Maharjan, N. et al. Downflow hanging sponge system: a self-sustaining option for wastewater treatment. In Wastewater Treatment (IntechOpen, London, UK, 2020) Available at https://www.intechopen.com/online-first/74120
Nurmiyanto, A. & Ohashi, A. Downflow hanging sponge (DHS) reactor for wastewater treatment—a short review. MATEC Web Conf. 280, 05004 (2019).
Hatamoto, M., Okubo, T., Kubota, K. & Yamaguchi, T. Characterization of downflow hanging sponge reactors with regard to structure, process function, and microbial community compositions. Appl. Microbiol. Biotechnol. 102, 10345–10352 (2018).
Tandukar, M., Uemura, S., Ohashi, A. & Harada, H. Combining UASB and the ‘fourth generation’ down-flow hanging sponge reactor for municipal wastewater treatment. Water Sci. Technol. 53, 209–218 (2006).
Chuang, H.-P. et al. Microbial community that catalyzes partial nitrification at low oxygen atmosphere as revealed by 16S rRNA and amoA genes. J. Biosci. Bioeng. 104, 525–528 (2007).
Imachi, H. et al. Cultivation of methanogenic community from subseafloor sediments using a continuous-flow bioreactor. ISME J. 5, 1913–1925 (2011).
Aoki, M. et al. A long-term cultivation of an anaerobic methane-oxidizing microbial community from deep-sea methane-seep sediment using a continuous-flow bioreactor. PLoS ONE 9, e105356 (2014).
Kato, S. et al. Biotic manganese oxidation coupled with methane oxidation using a continuous-flow bioreactor system under marine conditions. Water Sci. Technol. 76, 1781–1795 (2017).
Imachi, H. et al. Cultivable microbial community in 2-km-deep, 20-million-year-old subseafloor coalbeds through ~1000 days anaerobic bioreactor cultivation. Sci. Rep. 9, 2305 (2019).
Imachi, H. et al. Pelolinea submarina gen. nov., sp. nov., an anaerobic, filamentous bacterium of the phylum Chloroflexi isolated from subseafloor sediment. Int. J. Syst. Evol. Microbiol. 64, 812–818 (2014).
Imachi, H. et al. Sedimentibacter acidaminivorans sp. nov., an anaerobic, amino-acid-utilizing bacterium isolated from marine subsurface sediment. Int. J. Syst. Evol. Microbiol. 66, 1293–1300 (2016).
Imachi, H. et al. Isolation of an archaeon at the prokaryote-eukaryote interface. Nature 577, 519–525 (2020).
Miyazaki, M. et al. Sphaerochaeta multiformis sp. nov., an anaerobic, psychrophilic bacterium isolated from subseafloor sediment, and emended description of the genus Sphaerochaeta. Int. J. Syst. Evol. Microbiol. 64, 4147–4154 (2014).
Miyazaki, M. et al. Spirochaeta psychrophila sp. nov., a psychrophilic spirochaete isolated from subseafloor sediment, and emended description of the genus Spirochaeta. Int. J. Syst. Evol. Microbiol. 64, 2798–2804 (2014).
Nakahara, N. et al. Aggregatilinea lenta gen. nov., sp. nov., a slow-growing, facultatively anaerobic bacterium isolated from subseafloor sediment, and proposal of the new order Aggregatilineales ord. nov. within the class Anaerolineae of the phylum Chloroflexi. Int. J. Syst. Evol. Microbiol. 69, 1185–1194 (2019).
Spang, A. et al. Complex archaea that bridge the gap between prokaryotes and eukaryotes. Nature 521, 173–179 (2015).
Zaremba-Niedzwiedzka, K. et al. Asgard archaea illuminate the origin of eukaryotic cellular complexity. Nature 541, 353–358 (2017).
Liu, Y. et al. Expanded diversity of Asgard archaea and their relationships with eukaryotes. Nature 593, 553–557 (2021).
Ruff, S. E. et al. Global dispersion and local diversification of the methane seep microbiome. Proc. Natl Acad. Sci. USA 112, 4015–4020 (2015).
Chadwick, G. et al. Comparative genomics reveals electron transfer and syntrophic mechanisms differentiating methanotrophic and methanogenic archaea. PLoS Biol. 20, e3001508 (2022).
Cario, A., Oliver, G. C. & Rogers, K. L. Exploring the deep marine biosphere: challenges, innovations, and opportunities. Front. Earth Sci. 7, 225 (2019).
Jørgensen, B. B. & Boetius, A. Feast and famine—microbial life in the deep-sea bed. Nat. Rev. Microbiol. 5, 770–781 (2007).
Hoehler, T. M. & Jørgensen, B. B. Microbial life under extreme energy limitation. Nat. Rev. Microbiol. 11, 83–94 (2013).
Schink, B. & Stams, A. J. M. Syntrophism among prokaryotes. In The Prokaryotes: Prokaryotic Communities and Ecophysiology (eds. Rosenberg, E. et al.) 471–493 (Springer, 2013).
de Bok, F. A. M. et al. The first true obligately syntrophic propionate-oxidizing bacterium, Pelotomaculum schinkii sp. nov., co-cultured with Methanospirillum hungatei, and emended description of the genus Pelotomaculum. Int. J. Syst. Evol. Microbiol. 55, 1697–1703 (2005).
Imachi, H. et al. Pelotomaculum propionicicum sp. nov., an anaerobic, mesophilic, obligately syntrophic, propionate-oxidizing bacterium. Int. J. Syst. Evol. Microbiol. 57, 1487–1492 (2007).
Qiu, Y.-L. et al. Syntrophorhabdus aromaticivorans gen. nov., sp. nov., the first cultured anaerobe capable of degrading phenol to acetate in obligate syntrophic associations with a hydrogenotrophic methanogen. Appl. Environ. Microbiol. 74, 2051–2058 (2008).
Matsushita, S. et al. Anti-bacterial effects of MnO2 on the enrichment of manganese-oxidizing bacteria in downflow hanging sponge reactors. Microbes Environ. 35, ME20052 (2020).
Momper, L. et al. Rectinema subterraneum sp. nov, a chemotrophic spirochaete isolated from the deep terrestrial subsurface. Int. J. Syst. Evol. Microbiol. 70, 4739–4747 (2020).
Chuang, H.-P., Ohashi, A., Imachi, H., Tandukar, M. & Harada, H. Effective partial nitrification to nitrite by down-flow hanging sponge reactor under limited oxygen condition. Water Res. 41, 295–302 (2007).
Hatamoto, M., Koshiyama, Y., Kindaichi, T., Ozaki, N. & Ohashi, A. Enrichment and identification of methane-oxidizing bacteria by using down-flow hanging sponge bioreactors under low methane concentration. Ann. Microbiol. 61, 683–687 (2010).
Hatamoto, M., Yamamoto, H., Kindaichi, T., Ozaki, N. & Ohashi, A. Biological oxidation of dissolved methane in effluents from anaerobic reactors using a down-flow hanging sponge reactor. Water Res. 44, 1409–1418 (2010).
Hatamoto, M., Miyauchi, T., Kindaichi, T., Ozaki, N. & Ohashi, A. Dissolved methane oxidation and competition for oxygen in down-flow hanging sponge reactor for post-treatment of anaerobic wastewater treatment. Bioresour. Technol. 102, 10299–10304 (2011).
Hatamoto, M. et al. Potential of nitrous oxide conversion in batch and down-flow hanging sponge bioreactor systems. Sustain. Environ. Res. 24, 117–128 (2014).
Cao, L. T. T. et al. Biological oxidation of Mn(II) coupled with nitrification for removal and recovery of minor metals by downflow hanging sponge reactor. Water Res. 68, 545–553 (2015).
Yamaguchi, T. et al. A novel approach for toluene gas treatment using a downflow hanging sponge reactor. Appl. Microbiol. Biotechnol. 102, 5625–5634 (2018).
Matsushita, S. et al. Production of biogenic manganese oxides coupled with methane oxidation in a bioreactor for removing metals from wastewater. Water Res. 130, 224–233 (2018).
Onodera, T. et al. Characterization of the retained sludge in a down-flow hanging sponge (DHS) reactor with emphasis on its low excess sludge production. Bioresour. Technol. 136, 169–175 (2013).
Miyaoka, Y., Hatamoto, M., Yamaguchi, T. & Syutsubo, K. Eukaryotic community shift in response to organic loading rate of an aerobic trickling filter (down-flow hanging sponge reactor) treating domestic sewage. Microb. Ecol. 73, 801–814 (2016).
Park, M.-O., Ikenaga, H. & Watanabe, K. Phage diversity in a methanogenic digester. Microb. Ecol. 53, 98–103 (2006).
Wu, Q. & Liu, W.-T. Determination of virus abundance, diversity and distribution in a municipal wastewater treatment plant. Water Res. 43, 1101–1109 (2009).
Chien, I.-C., Meschke, J. S., Gough, H. L. & Ferguson, J. F. Characterization of persistent virus-like particles in two acetate-fed methanogenic reactors. PLoS One 8, e81040 (2013).
Girguis, P. R., Orphan, V. J., Hallam, S. J. & DeLong, E. F. Growth and methane oxidation rates of anaerobic methanotrophic archaea in a continuous-flow bioreactor. Appl. Environ. Microbiol. 69, 5472–5482 (2003).
Zhang, Y., Maignien, L., Zhao, X., Wang, F. & Boon, N. Enrichment of a microbial community performing anaerobic oxidation of methane in a continuous high-pressure bioreactor. BMC Microbiol. 11, 137 (2011).
Sauer, P., Glombitza, C. & Kallmeyer, J. A system for incubations at high gas partial pressure. Front. Microbiol. 3, 25 (2012).
Bhattarai, S. et al. Enrichment of sulfate reducing anaerobic methane oxidizing community dominated by ANME-1 from Ginsburg Mud Volcano (Gulf of Cadiz) sediment in a biotrickling filter. Bioresour. Technol. 259, 433–441 (2018).
Cassarini, C. et al. Enrichment of anaerobic methanotrophs in biotrickling filters using different sulfur compounds as electron acceptor. Environ. Eng. Sci. 36, 431–443 (2018).
Cassarini, C. et al. Anaerobic methane oxidation coupled to sulfate reduction in a biotrickling filter: reactor performance and microbial community analysis. Chemosphere 236, 124290 (2019).
Adams, M. M., Hoarfrost, A. L., Bose, A., Joye, S. B. & Girguis, P. R. Anaerobic oxidation of short-chain alkanes in hydrothermal sediments: potential influences on sulfur cycling and microbial diversity. Front. Microbiol. 4, 110 (2013).
Machdar, I., Sekiguchi, Y., Sumino, H., Ohashi, A. & Harada, H. Combination of a UASB reactor and a curtain type DHS (downflow hanging sponge) reactor as a cost-effective sewage treatment system for developing countries. Water Sci. Technol. 42, 83–88 (2000).
Judd, S. The status of membrane bioreactor technology. Trends Biotechnol. 26, 109–116 (2008).
Smith, A. L. et al. Perspectives on anaerobic membrane bioreactor treatment of domestic wastewater: a critical review. Bioresour. Technol. 122, 149–159 (2012).
Meulepas, R. J. W. et al. Enrichment of anaerobic methanotrophs in sulfate-reducing membrane bioreactors. Biotechnol. Bioeng. 104, 458–470 (2009).
Jagersma, G. C. et al. Microbial diversity and community structure of a highly active anaerobic methane-oxidizing sulfate-reducing enrichment. Environ. Microbiol. 11, 3223–3232 (2009).
Lettinga, G., van Velsen, A. F. M., Hobma, S. W., de Zeeuw, W. & Klapwijk, A. Use of the upflow sludge blanket (USB) reactor concept for biological wastewater treatment, especially for anaerobic treatment. Biotechnol. Bioeng. 22, 699–734 (1980).
Sekiguchi, Y., Kamagata, Y., Nakamura, K., Ohashi, A. & Harada, H. Fluorescence in situ hybridization using 16S rRNA-targeted oligonucleotides reveals localization of methanogens and selected uncultured bacteria in mesophilic and thermophilic sludge granules. Appl. Environ. Microbiol. 65, 1280–1288 (1999).
Tawfik, A., Ohashi, A. & Harada, H. Sewage treatment in a combined up-flow anaerobic sludge blanket (UASB)-down-flow hanging sponge (DHS) system. Biochem. Eng. J. 29, 210–219 (2006).
Onodera, T. et al. Development of a sixth-generation down-flow hanging sponge (DHS) reactor using rigid sponge media for post-treatment of UASB treating municipal sewage. Bioresour. Technol. 152, 93–100 (2014).
Tandukar, M., Ohashi, A. & Harada, H. Performance comparison of a pilot-scale UASB and DHS system and activated sludge process for the treatment of municipal wastewater. Water Res. 41, 2697–2705 (2007).
Hallam, S. J. et al. Reverse methanogenesis: testing the hypothesis with environmental genomics. Science 305, 1457–1462 (2004).
Nauhaus, K., Albrecht, M., Elvert, M., Boetius, A. & Widdel, F. In vitro cell growth of marine archaeal-bacterial consortia during anaerobic oxidation of methane with sulfate. Environ. Microbiol. 9, 187–196 (2007).
Wegener, G., Niemann, H., Elvert, M., Hinrichs, K. & Boetius, A. Assimilation of methane and inorganic carbon by microbial communities mediating the anaerobic oxidation of methane. Environ. Microbiol. 10, 2287–2298 (2008).
Hu, H., Natarajan, V. P. & Wang, F. Towards enriching and isolation of uncultivated archaea from marine sediments using a refined combination of conventional microbial cultivation methods. Mar. Life Sci. Technol. 3, 231–242 (2021).
Balch, W. E., Fox, G. E., Magrum, L. J., Woese, C. R. & Wolfe, R. S. Methanogens: reevaluation of a unique biological group. Microbiol. Rev. 43, 260–296 (1979).
Yokooji, Y. et al. Pantoate kinase and phosphopantothenate synthetase, two novel enzymes necessary for CoA biosynthesis in the Archaea. J. Biol. Chem. 284, 28137–28145 (2009).
Moench, T. & Zeikus, J. G. An improved preparation method for a titanium (III) media reductant. J. Microbiol. Methods 1, 199–202 (1983).
Miyashita, A. et al. Development of 16S rRNA gene-targeted primers for detection of archaeal anaerobic methanotrophs (ANMEs). FEMS Microbiol. Lett. 297, 31–37 (2009).
Sekiguchi, Y. et al. Sequence-specific cleavage of 16S rRNA for rapid and quantitative detection of particular groups of anaerobes in bioreactors. Water Sci. Technol. 52, 107–113 (2005).
Meechan, P. J. & Wilson, C. Use of ultraviolet lights in biological safety cabinets: a contrarian view. Appl. Biosaf. 11, 222–227 (2006).
Imachi, H., Sekiguchi, Y., Kamagata, Y., Ohashi, A. & Harada, H. Cultivation and in situ detection of a thermophilic bacterium capable of oxidizing propionate in syntrophic association with hydrogenotrophic methanogens in a thermophilic methanogenic granular sludge. Appl. Environ. Microbiol. 66, 3608–3615 (2000).
Stams, A. J., Grolle, K. C., Frijters, C. T. & van Lier, J. B. Enrichment of thermophilic propionate-oxidizing bacteria in syntrophy with Methanobacterium thermoautotrophicum or Methanobacterium thermoformicicum. Appl. Environ. Microbiol. 58, 346–352 (1992).
Uchino, Y. & Suzuki, K. A simple preparation of liquid media for the cultivation of strict anaerobes. J. Pet. Environ. Biotechnol. S3, 001 (2011).
Akinyemi, T. S., Shao, N. & Whitman, W. B. Genus Methanothrix. In Bergey’s Manual of Systematics of Archaea and Bacteria (John Wiley & Sons, 2020).

Cultivation of previously uncultured microorganisms with a continuous-flow down-flow hanging sponge (DHS) bioreactor, using a syntrophic archaeon culture obtained from deep marine sediment as a case study

Supplementary information

推荐阅读